International Journal of Innovative Technology and ...

The properties of concrete in fresh and hardened state are studied in the various papers that are used as a reference for this. Some of the properties are workability, compressive strength are the major one that are considered[4]. III. QUARRY DUST A. Origin of Quarry Dust: The quarry dust is the by-product which is formed in the

Characteristic studies on the mechanical properties of ...

was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The experimental results showed that the addition of quarry dust for a fine to coarse aggregate ratio of 0.6 was found to enhance the compressive properties as well as elastic modulus. Key words: Concrete, quarry dust, fillers, elastic modulus, compressive strength.

EFFECT OF QUARRY DUST AS PARTIAL ... - academia.edu

Attempts have been made to investigate some property of quarry dust and the suitability of those properties to enable quarry dust to be used as partial replacement material for sand in concrete. 2. MATERIALS AND PROPERTIES Cement In the present study an ordinary Portland cement (OPC 53 grade) was used.

Study on Compressive Strength of Quarry Dust as Fine ...

However, it is important to spot out with sand partially in concrete. he quarry dust samples that, as a waste material, the properties of stone ines are likely collected from Paritala region were studied and compared to vary with time. hen, ater that, the ineness of granite in terms of geotechnical properties. he physical properties ines could ...

CHAPTER 3 PROPERTIES OF MATERIALS - Shodhganga

aggregate (stone chips) and water. It is important to know the properties of constituent materials, as they impart strength and durability to the concrete. This chapter deals with the study of properties of various materials such as cement, sand, quarry dust, coarse aggregate, water, steel bar, plasticizer,

(PDF) An Experimental study on uses of Quarry Dust to ...

The study of Ilangovana et al. [12] gives attention to physical and chemical properties of quarry dust with From the experimental study, it is concluded that the respect to requirements of codal provision which are quarry dust can be used as a replacement for fine satisfied.

An Experimental study on compressive strength of Quarry ...

sand with quarry dust on the properties of concrete. 2. Literature Review The suitability of quarry dust as a sand replacement material shows that the mechanical properties are improved and also elastic modulus. The compressive strength achieved optimum by replacing fine aggregate with quarry dust in ratio of 60 : 40 as done by Hmaid Mir [1].

Quarry Dust Uses in a Construction Project

Jun 06, 2016· Quarry dust a by- product from crushing process during quarrying activities is good alternative during construction projects. It is used as substitute to sand to make quarry dust concrete which is believed to be stronger and more durable than the regular concrete materials. Uses of Quarry Dust. It can be used as substitute to sand wholly or partly.

Properties of Green Concrete Mix by Concurrent use of Fly ...

characteristics of Quarry Dust Concrete (QDC) containing 0% to 30% of fly ash. Based on the test results, it can be concluded that combined use of quarry dust and fly ash can be shown improved strength in concrete and also preserve the environment. Keywords: - Fly Ash, Properties, Quarry Dust, Strength I. INTRODUCTION

Improved Concrete Properties Using Quarry Dust as ...

The quarry dust is the by-product which is formed in the processing of the granite stones which broken downs into the coarse aggregates of different sizes. 3.2 PHYSICAL AND CHEMICAL PROPERTIES: The physical and chemical properties of quarry dust obtained by testing the sample as per the Indian Standards are listed in the below table

FLEXURAL AND TENSILE STRENGTH PROPERTIES OF …

suggest that concrete containing mixtures of lateritic sand and quarry dust can be reasonably used in structural elements as for normal concrete (concrete with river sand as fine aggregate). Keywords: concrete, flexural strength, tensile strength, lateritic sand, quarry dust.

(PDF) Properties of Micro Fine Quarry Dust Concrete ...

Properties of Micro Fine Quarry Dust Concrete. Wasiq Khan. Download with Google Download with Facebook or download with email. Properties of Micro Fine Quarry Dust Concrete. Download. Properties of Micro Fine Quarry Dust Concrete.

Engineering Properties Of Quarry Dust In Concrete

Engineering Properties Of Crusher Stone Dust. Behaviour of concrete on replacement of sand with quaries stone dust as fine p.Student, department of civil engineering, d.College of engineering and strength of concrete with crushed stone sand to that of river sand is 1.06 with a the physical and chemical properties of quarry rock dust obtained by.

Properties of Micro Fine Quarry Dust Concrete

reduce the usage of cement in the construction industry. With that in mind, Micro Fine Quarry Dust (MFQD) is a white material which is a buy product from the quarry is introduced to replace cement. In this paper, the replacement of cement by MFQD in concrete mixture seen to be a reliable source in terms of strength and its rate

Comparison of physical and mechanical properties of river ...

PDF | This study compared the physical and mechanical properties of river sand concrete with quarry dust concrete. The constituent materials were batched by weight. The water-cement ratio and mix ...

Effect of quarry rock dust on the flexural strength of ...

Portland limestone cement, river sand and quarry rock dust both of 2 mm maximum size as fine aggregate, and 14 mm crushed rock coarse aggregate were used for the concrete The particle size distribution and the physical properties of the fine and coarse aggregates are shown in Fig. 1 and Table 1 respectively. The fine and coarse aggregates satisfied the BS EN 12620:2002 + A1:2008 …

EFFECT OF CHARACTERIZATION PROPERTIES ON …

The physical properties of the natural and quarry dust are compared in Table. 2. Quarry rock dust The Quarry Rock Dust obtained from local resource Siddheswar's Crushers (P) Ltd., Umred road, Nagpur was used in concrete to cast test cubes, beams and cylinder. The physical and chemical properties of Quarry Rock Dust obtained by testing the ...

Influence of Admixtures and Quarry Dust on the Physical ...

INFLUENCE OF ADMIXTURES AND QUARRY DUST ON THE PHYSICAL PROPERTIES OF FRESHLY MIXED HIGH PERFORMANCE CONCRETE M. Fauzi M. Zain l, Md. Safiuddin 2, T. K. Song l, H.B.Mahmud 3, and Y. Matsufuji 4 1Department of Civil and Structural Engineering, University Kebangsaan Malaysia 2Department of Civil and Environmental Engineering, University of ...

EXPERIMENTAL INVESTIGATION ON MECHANICAL AND …

of concrete are examined by using quarry dust as fine aggregate. In this study, the cubes casted in 0%, 5%, 10%, 15%, 20% and 25% of quarry dust as fine aggregate. Key Words: Fine Aggregate, Waste material, Quarry dust, Compressive Strength, Durability Properties. 1. INTRODUCTION Concrete is the second highest and the most popular building

Research Paper Structural Properties of Laterite - Quarry ...

Quarry dust 2.43 16.72 65.66 3.92 - - 3.56 2.21 0.88 - Physical properties of the aggregate Table 2 shows the physical properties of the aggregate used in the moulding of blocks. The specific gravity of the quarry dust and laterite were found to be 2.52 and 2.65 respectively. These values are within the

Effect of Quarry Dust on The Physical Properties of High ...

This paper present a report on the possibility of developing high performance concrete (HPC) using quarry dust as part of fine aggregates. Quarry dust was used to replace 20% of sand in silica fume-quarry dust (SFQD) and silica fume (SF) concretes. Besides, silica fume was used as 10% replacement of cement in both SF and SFQD concretes.

Comparison of physical and mechanical properties of river ...

This study compared the physical and mechanical properties of river sand concrete with quarry dust concrete. The constituent materials were batched by weight. The water-cement ratio and mix ratio selected for the experimental investigation were 0.55 and 1:2:4, respectively. The specimens were cured for 7, 14, 21 and 28 days. Slump, density and compressive strength tests were carried out.

Physical And Chemical Properties Of Quarry Dust

physical and chemical composition of quarry dust. Evaluation of Soil-Quarry Dust Mixtures Reinforced with - Ejge.com. oriented fibers greatly influences the performance of Soil Quarry dust mix physical properties ...

Suitability of Quarry Dust as Partial Replacement Material ...

Suitability of Quarry Dust as Partial Replacement Material for Sand in Concrete ... material for sand in concrete. The properties of quarry dust that were determined are aggregate crushing value ...

An Experimental Study On Usage Of Quarry Dust As Partial ...

Quarry Rock Dust in concrete.Babu K.K., Radhakrishnan R. and Nambiar E.K.K. (Compressive Strength of Brick Masonry with Alternative Aggregate Mortar) reported - that the Physical and chemical properties of quarry rock dust is satisfied the requirements of code provision of IS 4032/1968 in properties studies. Natural

THE EFFECT OF QUARRY DUST WITH CEMENT BY-PRODUCTS ON ...

Hameed, and Sekar. (2009). Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as Fine Aggregate. Hmaid Mir, A. (2015). Improved Concrete Properties Using Quarry Dust as Replacement for Natural Sand. International Journal of …

physical properties of quarry dust concrete - bondhumahal.in

Quarry Dust Properties Ppt . Stone crusher dust as a fine aggregate in Concrete for paving blocks. Some of the physical and mechanical properties of paving blocks ... river sand with quarry dust without the inclusion of fly ash resulted in a reduction in the.

Use of Quarry Dust to Replace Sand in Concrete – An ...

as quarry dust. The quarry dust is used to sprinkle over the newly laid bituminous road as filler between the bitumen and coarse aggregate and manufacturing of hollow blocks. Various physical properties of the concrete materials are tabulated in Table 1. Table 1: Properties of the materials Material Properties

Top Benefits of Using Quarry Dust in Construction Project ...

Jul 08, 2016· Top Benefits of Using Quarry Dust in Construction Project ... Addition of quarry dust improves the physical and mechanical properties of concrete. Due to its high volume of fine particles, it proves to be very effective in assuring very good cohesiveness of concrete. ...